Product ID:SKC-NF CLEANER/REMOVER
MSDS Date:01/29/1993
FSC:6850
NIIN:01-240-7717
MSDS Number: BJPHH

MAGNAFLUX CORPORATION

7301 W.AINSLIE ST
HARWOOD HEIGHTS, IL 60656
US

Emergency Phone: 708-867-8000/800-424-9300(CHEMTREC)

Info Phone: 708-867-8000

Preparer: BRUCE C. GRAHAM, CH. CHEM

Cage: 37676

ILLINOIS TOOL WORKS INC MAGNAFLUX DIV

GLENVIEW, IL 60025 US

Telephone: 847-657-5300/

Cage: 37676

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: 95.0%

OSHA PEL 350 PPM/450 STEL

ACGIH TLV: 350 PPM/450STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYLAL (DIMETHOXYMETHANE)

CAS: 109-87-5

RTECS: PA8750000

Fraction By Weight: 1.0%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9192

TERT-BUTYL ALCOHOL (SARA III)

CAS: 75-65-0

RTECS: EO1925000

Fraction By Weight: 1.00%

OSHA PEL 100 PPM

ACGIH TLV: 100PPM 9394

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 5.0%

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;93

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES MILD IRRITATION TO EYES
AND SKIN. NOT ABSORBED THROUGH SKIN IN SIGNIFICANT AMOUNTS. MAY
CAUSE NAUSE, DROWSINESS AND UNCONSCIOUSNESS AT HIGH CONCENTRATIONS.
EXPOSURE ABOVE TLV CAN RESULT IN CLUMSINESS AND POOR JUDGEMENT
JUST LIKE INGESTION OF ALCOHOL. UNCONSCIOUS VICTIM IS AT GREATER
RISK OF FATALITY.
Effects of Overexposure:INHALATION: VAPORS MAY CAUSE DROWSINESS, NAUSEA
AND UNCONSCIOUS AT HIGH CONCENTRATIONS; EYES: LIQUID CONTACT MAY
CAUSE IRRITATION; SKIN: CAUSES IRRITATION BY DISSOLVING SKIN OILS.
NOT ABSORBED IN SIGN IFICANT AMOUNTS. INGESTION:CAUSES GASTRIC
UPSET. LOW SINGLE DOSE TOXICITY IN TEST ANIMALS.
Medical Cond Aggravated by Exposure:NOT STATED BY MANUFACTURER.

First Aid:INHAL:REMOVE TO FRESH AIR. IF BREATH DIFFIC GIVE OXYGEN.
SKIN:REMOVE CONTAMINATED CLOTHES. WASH W/FLOWING WATER. USE
SOOTHING LOTION. IF IRRIT PERSISTS GET MED ATTN. EYES:IMMED FLUSH
W/STEADY GENTLE F LOW OF WATER LIFTING EYELIDS. GET MED ATTN.
INGEST:DO NOT INDUCE VOMIT. IF VOMIT IS INHALED IT MAY CAUSE
ASPHYXIATION. CONTACT DOCTOR IMMED.

Flash Point:NONE
Lower Limits:10%
Upper Limits:15%
Extinguishing Media:NONE NOTED; HOWEVER, USE SUITABLE EXTINGUISHING
MEDIA FOR SURROUNDING FIRES.
Fire Fighting Procedures:WEAR APPROPRIATE SAFETY EQUPMT INCLUDING SCBA.
KEEP CONTAINERS COOL W/WATER SPRAY. DO NOT SPRAY WATER ON BURNING
PRODUCT.
Unusual Fire/Explosion Hazard:VAPORS PARTIALLY DECOMPOSE TO TOXIC GASES
WHEN EXPOSED TO FLAME, ARCS, OR RED HOT SURFACES. AEROSOL CANS MAY
BURST IN TEMPERATURE OVER 130F.

Spill Release Procedures:SMALL SPILL(<1QT):WIPE OR MOP UP & PLACE IN
CLOSED DURMS.SEGGREGATE LEAKING AEROSOL CANS,DEPRESSURIZE & PLACE
IN DOT APPROVED DISPOSAL CONTAINER.TREAT EMPTY CANS AS HAZ MATLS.
LG SPILLS:EVACUATE AREA. CLEAN UP CREW WEAR RESP PROTECTION.FOLLOW
ABOVE.

Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA. AVOID AGAINST PHYSICAL DAMAGE. DO NOT HEAT AEROSOL
CAN ABOVE 130F. DO NOT DROP AEROSOL CANS.
Other Precautions:DO NOT BREATHE VAPORS. DO NOT SMOKE WHILE USING. DO
NOT HEAT ABOVE 130F(54C). AVOID FREQUENT OR PROLONGED SKIN CONTACT.
DO NOT USE AROUND FLAMES, ARCS, RED HOT SURFACES SO AS TO AVOID
EXPOSURE TO PHOS GENEGAS AND HYDROCHLORIC ACID GAS.

Respiratory Protection:WEAR A RESPIRATOR WITH CHEMICAL CARTRIDGE IN
POORLY VENTILATED AREAS. IN CONFINED, UNVENTILATED SPACES AREAS,
WEAR A FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION MUST BE SUFFICIENT TO KEEP BELOW 350PPM
LIMIT.IT IS PREFERRED TO USE IN SPRAY BOOTH OR NEXT TO EXHST
Protective Gloves:NITRILE RUBBER GLOVES TO AVOID CONTACT.
Eye Protection:FULL GOGGLES. WHEN SPRAYING OR POURING.
Other Protective Equipment:EITHER USE IN A SPRAY BOOTH OR NEXT TO AN
EXHAUST VENT. REMEMBER THAT THE VAPORS TEND TO SETTLE TO THE FLOOR.
Work Hygienic Practices:AVOID SKIN CONTACT. WASH THOROUGHLY AFTER
HANDLING OR USE. LAUNDER CONTAMINATED CLOTTHES.
Supplemental Safety and Health
NO SPECS APPLIES TO THIS NSN; PRODUCT SAME AS YOU MAY SEE UNDER SEVERAL
ENTRIES OF MIL-I-25135E IN HMIS. THIS NSN MAY BE SOLE SOURCE FOR
MAGNAFLUX CORP. THIS UPDATED MSDS COMPRISED OF MFG'S MSDS DTD 2
9JAN93 & PREVIOUS HMIS RECORD MSDS DTD 01MAY90.

HCC:V2
Boiling Pt:B.P. Text:162F/72.2C
Vapor Pres:230MM@100F
Vapor Density:4.0
Spec Gravity:1.3
pH:NEUTRA
Evaporation Rate & Reference:>3 (ETHYL ALCOHOL=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR COLORLESS MOBILE LIQUID (BEFORE FILLING
AEROSOL CANS) W/ A SWEET ODOR.
Percent Volatiles by Volume:100%

Stability Indicator/Materials to Avoid:NO
COMBUSTION OR HEATIANG ABOVE 130F MAY PRODUCE HYDROCHLORIC ACID GAS,
PHOSGENE GAS, OXIDES OF CARBON & SOOT.
Stability Condition to Avoid:PARTIALLY DECOMPOSES IN FLAME, ARCS, OR
NEAR RED HOT SURFACES.
Hazardous Decomposition Products:COMBUSTION OR HEATING ABOVE 130F MAY
PRODUCE HYDROCHLORIC ACID GAS, PHOSGENE GAS AND OXIDES OF CARBON.
Conditions to Avoid Polymerization:EXTREME TEMPERATURES.

Waste Disposal Methods:PER MAGNAFLUX, DISPOSE OF LIQUID AS EPA
HAZARDOUS WASTE #F002; LIQUID MAY BE SENT TO SOLVENT RECLAIMER.
ENSURE THAT AEROSOL CANS ARE EMPTY AND DEPRESSURISED BEFORE
DISCARDING UNLESS WASTE FACILITY IS APPROVED TO ACCEPT THEM AS IS.
ABIDE BYALL RULES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.